MLU FORUM  

Go Back   MLU FORUM > MILITARY VEHICLES > The Restoration Forum

Notices

Reply
 
Thread Tools Display Modes
  #1  
Old 05-11-16, 13:06
Ken Thomas Ken Thomas is offline
Registered User
 
Join Date: May 2010
Location: Australia
Posts: 31
Default Chev 216 oil system

Hi everyone. Re oil system on 216 Chev engine. Regards to Phil Waterman, I used the system of checking you proposed 3/7/16 for checking the aiming etc. & added a further test. I filled the troughs with grease & rotated the crank several times. Then with a square off the top of the sump on vertical lines going down to where the oil jets hit the sump sides, I could get a further indication of alignment. Doing this I found one dipper slightly out of alignment to the nozzle of the oil jet. From the first picture you will see that it is not much, & it was the path marked out by the bottom of the dipper, which on closer examination proved to be bent out of vertical. As the dipper has a wider section of catchment as it goes upward to the conrod, it would perhaps have not been of much significance, but a touch with a soft hammer & a retest aligned it. See second picture. I did these tests without allowance for a sump gasket for an indication of “clearance” problems. Thanks for your advice, I feel confident all is well.
Ken Thomas.
C60 Long
Attached Thumbnails
PA060589.JPG   PA060587.JPG   PA060588.JPG  
Reply With Quote
  #2  
Old 05-11-16, 16:34
David Herbert David Herbert is offline
Registered User
 
Join Date: Mar 2010
Location: Ayrshire, Scotland - previously Suffolk
Posts: 512
Default

What a good, simple way to check. You get a gold star !

David
Reply With Quote
Reply

Thread Tools
Display Modes

Posting Rules
You may not post new threads
You may not post replies
You may not post attachments
You may not edit your posts

BB code is On
Smilies are On
[IMG] code is On
HTML code is Off

Forum Jump

Similar Threads
Thread Thread Starter Forum Replies Last Post
Help with Ignition System ajmac The Carrier Forum 18 01-08-13 08:06
Windsor oil system stephen crowhurst The Carrier Forum 4 02-04-12 23:57
Brake system 13 Cab Chev jason meade The Restoration Forum 7 21-03-12 02:30
P.A. system on arm'd cars? Dave Block The Softskin Forum 5 29-01-12 19:18
216 Chev crankcase vent system huphuphup The Restoration Forum 0 06-03-04 07:51


All times are GMT +2. The time now is 04:12.


Powered by vBulletin® Version 3.8.4
Copyright ©2000 - 2021, Jelsoft Enterprises Ltd.
Copyright © Maple Leaf Up, 2003-2016